- 必威体育下载

姓名
邮箱
手机号码
标题
留言内容
验证码

Abstract

Silicon heterojunction (SHJ) solar cells have attracted much attention in the international photovoltaic market due to their high efficiencies and low costs. The quality of amorphous silicon/crystalline silicon (a-Si:H/c-Si) interfaces of SHJ solar cells has a key influence on the device performance. Therefore, the carrier recombination rate of a-Si:H/c-Si interface needs to be effectively controlled. In addition, as the important component of SHJ solar cells, the p-type emitter must meet the requirements for high conductivity, high light transmittance, and energy band matching with c-Si. The research contents and the relevant achievements of this paper include the following aspects. Firstly, in order to reduce the surface defects and realize the energy band alignment of a-Si:H/c-Si interface, the effect of passivation layer on passivation effect is studied. An ultra-thin buffer layer deposited by a low power and a high hydrogen dilution ratio is inserted between the conventional passivation layer and c-Si to improve the passivation effect and broaden the process window of passivation layer. The effects of the buffer layer thickness and hydrogen dilution ratio on passivation quality are further studied, and the best experimental conditions of buffer layer are obtained. The experimental results show that the sample with double-layered passivation layer is more stable than the conventional passivation layer. The minority carrier lifetime of the sample with single conventional passivation layer is 3.8 ms and the iV _OCis 712 mV, while the minority carrier lifetime of the sample with double-layered passivation layer is 4.197 ms and the iV _OCis 726 mV. Secondly, for the p-type emitters of silicon heterojunction solar cells, the effects of doping level on the photoelectric properties of p-type hydrogenated nanocrystalline silicon (nc-Si:H) thin films are studied. On this basis, the p ⁺⁺-nc-Si:H/p-nc-Si:H double-layer emitter with wide band gap and high conductivity is designed and fabricated. By analyzing the optical and electrical properties of different emitters, it is found that p-nc-Si:H has good electrical and optical properties. Owing to the high doping efficiency of nc-Si, a small amount of doping can obtain high conductivity. Lightly doped p-nc-Si:H provides a better contact with the passivation layer, while heavily doped p ⁺⁺-nc-Si:H can not only provide enough built-in electric field, but also improve the contact characteristics of p/ITO, thus enhancing the output characteristics of the cell. At the same time, the deposition of p-nc-Si:H layer with high hydrogen dilution ratio can also implement the hydrogen plasma treatment on the passivation layer, the reduction of the dangling bonds on the surface of the c-Si, the enhancement of the chemical passivation effect, and thus improving the open circuit voltage of the cell. Finally, a silicon heterojunction solar cell with an efficiency of 20.96% is obtained based on the commercial czochralski silicon wafer, with an open circuit voltage of 710 mV, a short circuit current density of 39.88 mA/cm ²and filling factor of 74.02%.

Keywords:

Authors and contacts

Corresponding author:Hou Guo-Fu,gfhou@nankai.edu.cn

Funds:Project supported by the National Key R&D Program of China (Grant No. 2018YFB1500402) and the National Natural Science Foundation of China (Grant No. 62074084)

FullText HTML: translate this paragraph

References

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]
[30]
[31]
[32]
[33]

Cited By

DownLoad: Full-Size Img PowerPoint

H₂∶SiH₄∶TMB	J_SC/mA·cm^–2	V_OC/V	FF/%	Eff/%
120∶4∶4	38.7	0.709	66.57	18.26
160∶4∶4	38.91	0.710	69.08	19.08
200∶4∶4	39.15	0.709	70.84	19.66
240∶4∶4	38.4	0.708	65.56	17.8

DownLoad: CSV

H₂∶SiH₄∶TMB	J_SC/mA·cm^–2	V_OC/V	FF/%	Eff/%
200∶4∶4	39.15	0.709	70.84	19.66
200∶4∶4.8	39.37	0.708	71.86	20.03
200∶4∶5.6	38.79	0.709	69.71	19.17
200∶4∶6.4	38.7	0.710	63.20	17.3

DownLoad: CSV

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]
[30]
[31]
[32]
[33]

[1]	Xiao Yi-Yao, He Jia-Hao, Chen Nan-Kun, Wang Chao, Song Ning-Ning.Enhanced microwave absorption performance of large-sized monolayer two-dimensional Ti₃C₂T_xbased on loaded Fe₃O₄nanoparticles. Acta Physica Sinica, 2023, 72(21): 217501.doi:10.7498/aps.72.20231200
[2]	Zhao Jian-Ning, Wei Dong, Lü Guo-Zheng, Wang Zi-Cheng, Liu Dong-Huan.Transient thermal rectification effect of one-dimensional heterostructure. Acta Physica Sinica, 2023, 72(4): 044401.doi:10.7498/aps.72.20222085
[3]	Wang Chen, Wen Pan, Peng Cong, Xu Meng, Chen Long-Long, Li Xi-Feng, Zhang Jian-Hua.Effect of passivation layer on back channel etching InGaZnO thin film transistors. Acta Physica Sinica, 2023, 72(8): 087302.doi:10.7498/aps.72.20222272
[4]	Cao Yu, Liu Chao-Ying, Zhao Yao, Na Yan-Ling, Jiang Chong-Xu, Wang Chang-Gang, Zhou Jing, Yu Hao.Optimization of interfacial characteristics of antimony sulfide selenide solar cells with double electron transport layer structure. Acta Physica Sinica, 2022, 71(3): 038802.doi:10.7498/aps.71.20211525
[5]	Wang Qi, Yan Ling-Ling, Chen Bing-Bing, Li Ren-Jie, Wang San-Long, Wang Peng-Yang, Huang Qian, Xu Sheng-Zhi, Hou Guo-Fu, Chen Xin-Liang, Li Yue-Long, Ding Yi, Zhang De-Kun, Wang Guang-Cai, Zhao Ying, Zhang Xiao-Dan.Perovskite/silicon heterojunction tandem solar cells: Advances in optical simulation. Acta Physica Sinica, 2021, 70(5): 057802.doi:10.7498/aps.70.20201585
[6]	Chen Jun-Fan, Ren Hui-Zhi, Hou Fu-Hua, Zhou Zhong-Xin, Ren Qian-Shang, Zhang De-Kun, Wei Chang-Chun, Zhang Xiao-Dan, Hou Guo-Fu, Zhao Ying.Passivation optimization and performance improvement of planar a-Si:H/c-Si heterojunction cells in perovskite/silicon tandem solar cells. Acta Physica Sinica, 2019, 68(2): 028101.doi:10.7498/aps.68.20181759
[7]	Tan Man-Lin, Zhou Dan-Dan, Fu Dong-Ju, Zhang Wei-Li, Ma Qing, Li Dong-Shuang, Chen Jian-Jun, Zhang Hua-Yu, Wang Gen-Ping.Performance investigation of black silicon solar cells with surface passivated by BiFeO3/ITO composite film. Acta Physica Sinica, 2017, 66(16): 167701.doi:10.7498/aps.66.167701
[8]	Zhang Xiao-Yu, Zhang Li-Ping, Ma Zhong-Quan, Liu Zheng-Xin.Numerical simulation of silicon heterojunction solar cells with Si/Si1-xGex quantum wells. Acta Physica Sinica, 2016, 65(13): 138801.doi:10.7498/aps.65.138801
[9]	Xu Zhong-Hua, Chen Wei-Bing, Ye Wei-Qiong, Yang Wei-Feng.A Study of tandem structure organic solar cells composed of polymer and small molecular sub-cells. Acta Physica Sinica, 2014, 63(21): 218801.doi:10.7498/aps.63.218801
[10]	Yu Huang-Zhong.Progress in the blend stacked structure of organic solar cells. Acta Physica Sinica, 2013, 62(2): 027201.doi:10.7498/aps.62.027201
[11]	Xue Yuan, Gao Chao-Jun, Gu Jin-Hua, Feng Ya-Yang, Yang Shi-E, Lu Jing-Xiao, Huang Qiang, Feng Zhi-Qiang.Study on the properties and optical emission spectroscopy of the intrinsic silicon thin film in silicon heterojunction solar cells. Acta Physica Sinica, 2013, 62(19): 197301.doi:10.7498/aps.62.197301
[12]	Cao Yu, Zhang Jian-Jun, Li Tian-Wei, Huang Zhen-Hua, Ma Jun, Ni Jian, Geng Xin-Hua, Zhao Ying.Optimization of the longitudinal structure of intrinsic layer in microcrystalline silicon germanium solar cell. Acta Physica Sinica, 2013, 62(3): 036102.doi:10.7498/aps.62.036102
[13]	Zheng Xue, Yu Xue-Gong, Yang De-Ren.Passivation property of -Si：H/SiNx stack-layer film in crystalline silicon solar cells. Acta Physica Sinica, 2013, 62(19): 198801.doi:10.7498/aps.62.198801
[14]	Hou Guo-Fu, Lu Peng, Han Xiao-Yan, Li Gui-Jun, Wei Chang-Chun, Geng Xin-Hua, Zhao Ying.Improving the light-soaking stability of a-Si: H/μc-Si: H tandem solar cells. Acta Physica Sinica, 2012, 61(13): 138401.doi:10.7498/aps.61.138401
[15]	Zhang Xiao-Dan, Zheng Xin-Xia, Wang Guang-Hong, Xu Sheng-Zhi, Yue Qiang, Lin Quan, Wei Chang-Chun, Sun Jian, Zhang De-Kun, Xiong Shao-Zhen, Geng Xin-Hua, Zhao Ying.High efficiency amorphous/microcrystalline silicon tandem solar cells deposited in a single chamber system. Acta Physica Sinica, 2010, 59(11): 8231-8236.doi:10.7498/aps.59.8231
[16]	Sun Ming-Zhao, Zhang Chun-Min, Sun Xiao-Ping.Octagonal split resonant rings composite metal-wires to realize negative refraction. Acta Physica Sinica, 2010, 59(8): 5444-5449.doi:10.7498/aps.59.5444
[17]	Zhou Jun, Di Ming-Dong, Sun Tie-Tun, Sun Yong-Tang, Wang Hao.Effects of substrate resistivity and interface defect density on performance of solar cell with silicon heterojunctions. Acta Physica Sinica, 2010, 59(12): 8870-8876.doi:10.7498/aps.59.8870
[18]	Meng Li-Jun, Xiao Hua-Ping, Tang Chao, Zhang Kai-Wang, Zhong Jian-Xin.Formation and thermal stability of compound stucture of carbon nanotube and silicon nanowire. Acta Physica Sinica, 2009, 58(11): 7781-7786.doi:10.7498/aps.58.7781
[19]	Yuan Yu-Jie, Hou Guo-Fu, Xue Jun-Ming, Han Xiao-Yan, Liu Yun-Zhou, Yang Xing-Yun, Liu Li-Jie, Dong Pei, Zhao Ying, Geng Xin-Hua.The influence of n-layer on structural properties of i-layer in n-i-p μc-Si∶H thin film solar cells. Acta Physica Sinica, 2008, 57(6): 3892-3897.doi:10.7498/aps.57.3892
[20]	Zhao Lei, Zhou Chun-Lan, Li Hai-Ling, Diao Hong-Wei, Wang Wen-Jing.Optimizing polymorphous silicon back surface field of a-Si(n)/c-Si(p) heterojunction solar cells by simulation. Acta Physica Sinica, 2008, 57(5): 3212-3218.doi:10.7498/aps.57.3212

Catalog

Vol. 70, Issue 18 - 2021-09-20

Metrics

Abstract views:7028
PDF Downloads:260
Cited By:0

Search

Article