Preparation and characteristics of ultra-wide Ga<sub>2</sub>O<sub>3</sub> nanoribbons up to millimeter-long level without catalyst

姓名
邮箱
手机号码
标题
留言内容
验证码

Abstract

Gallium oxide (Ga ₂O ₃) single crystal nanoribbons have the potential applications in electronic devices due to their unique properties. However, the current small surface area makes the fabrication of device based on this nano-material very complex and challenging, and the introduction of catalyst also makes the growth process of Ga ₂O ₃nanomaterial complicated and hard to control. Therefore, it is very important to study the growth method and physical mechanism of Ga ₂O ₃nanoribbon with the larger surface area without catalyst. In this paper, the carbothermal reduction method is used to grow the Ga ₂O ₃nanomaterial. In this paper, the gallium oxide powder mixes with the carbon nanotubes at a mass ratio of 1:1.5 without the catalyst, and then they are put into a high temperature diffusion furnace for the growth of Ga ₂O ₃nanomaterials with different structures on silicon-based substrates by controlling the reaction temperature. In this paper, it is found that the reaction temperature directly affects the diameter and ratio of gallium oxide nanostructures. The reason is that the bonding energy of gallium oxide crystal is different in different crystal directions which leads to the different growth speed. The interface energy along the growth direction is the smallest and the growth speed is the fastest, while the growth speed along the vertical direction is slow. Finally, the crystal gradually grows into nanoriband, nanometer sheet and other structures. In addition, the ultra-wide β-Ga ₂O ₃single crystal nanobelt up to the millimeter level was prepared in this paper. This nanobelt’s lateral dimension is observed to reach 44.3 μm under the scanning electron microscope (SEM), and the transmission electron microscope (TEM) is used to confirm that the nanoribbons have a single crystal structure. Further, Raman spectroscopy (Raman) shows that the β-Ga ₂O ₃nanoribbons grown by this method have the smaller strain and the lower defect density. Additionally, the room temperature photoluminescence spectrum (PL) test shows that the gallium oxide nanoribbon emits a stable and high-brightness blue light at 425 nm at the excitation wavelength of 295 nm. This growth method can provide a useful way for the preparation of device-level gallium oxide nanoribbons in the future.

Keywords:

Authors and contacts

Corresponding author:Chen Hai-Feng,chenhaifeng@xupt.edu.cn

Funds:Project supported by the National Natural Science Foundation of China (Grant No. 61306131) and the Natural Science Basic Research Program of Shaanxi Province, China (Grant No. 2020JM-581)

FullText HTML: translate this paragraph

References

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]
[30]
[31]

Cited By

DownLoad: Full-Size Img PowerPoint

Samples	Ga₂O₃/g	CNTs/g	Growth temperature/℃	Times/min	N₂carrier gas /sccm
A	1	1.5	800	90	2
B	1	1.5	850	90	2
C	1	1.5	900	90	2
D	1	1.5	950	90	2

DownLoad: CSV

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]
[30]
[31]

[1]	Su Ran, Xi Zhao-Ying, Li Shan, Zhang Jia-Han, Jiang Ming-Ming, Liu Zeng, Tang Wei-Hua.GaSe/β-Ga₂O₃heterojunction based self-powered solar-blind ultraviolet photoelectric detector. Acta Physica Sinica, 2024, 73(11): 118502.doi:10.7498/aps.73.20240267
[2]	Yi Zi-Qi, Wang Yan-Ming, Wang Shuo, Sui Xue, Shi Jia-Hui, Yang Yi-Han, Wang De-Yu, Feng Qiu-Ju, Sun Jing-Chang, Liang Hong-Wei.Performance of UV photodetector of mechanical exfoliation prepared PEDOT:PSS/β-Ga₂O₃microsheet heterojunction. Acta Physica Sinica, 2024, 73(15): 157102.doi:10.7498/aps.73.20240630
[3]	Liu Wei, Feng Qiu-Ju, Yi Zi-Qi, Yu Chen, Wang Shuo, Wang Yan-Ming, Sui Xue, Liang Hong-Wei.Preparation and ultraviolet detection performance of Cu dopedβ-Ga₂O₃thin films. Acta Physica Sinica, 2023, 72(19): 198503.doi:10.7498/aps.72.20230971
[4]	Zhou Zhan-Hui, Li Qun, He Xiao-Min.Electron transport mechanism in AlN/β-Ga₂O₃heterostructures. Acta Physica Sinica, 2023, 72(2): 028501.doi:10.7498/aps.72.20221545
[5]	Zhang Mao-Lin, Ma Wan-Yu, Wang Lei, Liu Zeng, Yang Li-Li, Li Shan, Tang Wei-Hua, Guo Yu-Feng.Investigation of high-temperature performance of WO₃/β-Ga₂O₃heterojunction deep-ultraviolet photodetectors. Acta Physica Sinica, 2023, 72(16): 160201.doi:10.7498/aps.72.20230638
[6]	Wang Lu-Xuan, Liu Yi-Tong, Shi Fang-Yuan, Qi Xian-Wen, Shen Han, Song Ying-Lin, Fang Yu.Broadband ultrafast photogenerated carrier dynamics induced by intrinsic defects in $\boldsymbol\beta$ -Ga₂O₃. Acta Physica Sinica, 2023, 72(21): 214202.doi:10.7498/aps.72.20231173
[7]	Zhu Yong-Qi, Liu Yu-Xue, Shi Yang, Wu Cong-Cong.High performance perovskite solar cells synthesized by dissolving FAPbI₃single crystal. Acta Physica Sinica, 2023, 72(1): 018801.doi:10.7498/aps.72.20221461
[8]	.Effect of film thickness on photoelectric properties of β-Ga2O3 films by radio frequency magnetron sputtering*. Acta Physica Sinica, 2021, (): .doi:10.7498/aps.70.20211744
[9]	Long Ze, Xia Xiao-Chuan, Shi Jian-Jun, Liu Jun, Geng Xin-Lei, Zhang He-Zhi, Liang Hong-Wei.Temperature dependent characteristics of Ni/Au vertical Schottky diode based on mechanically exfoliated beta-Ga₂O₃single crystal. Acta Physica Sinica, 2020, 69(13): 138501.doi:10.7498/aps.69.20200424
[10]	Hong Zi-Fan, Chen Hai-Feng, Jia Yi-Fan, Qi Qi, Liu Ying-Ying, Guo Li-Xin, Liu Xiang-Tai, Lu Qin, Li Li-Jun, Wang Shao-Qing, Guan Yun-He, Hu Qi-Ren.Characteristics of Ga₂O₃epitaxial films on seed layer grown by magnetron sputtering. Acta Physica Sinica, 2020, 69(22): 228103.doi:10.7498/aps.69.20200810
[11]	Ma Teng-Yu, Li Wan-Jun, He Xian-Wang, Hu Hui, Huang Li-Juan, Zhang Hong, Xiong Yuan-Qiang, Li Hong-Lin, Ye Li-Juan, Kong Chun-Yang.Size Regulation and Photoluminescence Properties ofβ-Ga₂O₃Nanomaterials. Acta Physica Sinica, 2020, 69(10): 108102.doi:10.7498/aps.69.20200158
[12]	Guo Dao-You, Li Pei-Gang, Chen Zheng-Wei, Wu Zhen-Ping, Tang Wei-Hua.Ultra-wide bandgap semiconductor of β-Ga₂O₃and its research progress of deep ultraviolet transparent electrode and solar-blind photodetector. Acta Physica Sinica, 2019, 68(7): 078501.doi:10.7498/aps.68.20181845
[13]	Feng Qiu-Ju, Li Fang, Li Tong-Tong, Li Yun-Zheng, Shi Bo, Li Meng-Ke, Liang Hong-Wei.Growth and characterization of grid-like β-Ga2O3 nanowires by electric field assisted chemical vapor deposition method. Acta Physica Sinica, 2018, 67(21): 218101.doi:10.7498/aps.67.20180805
[14]	Li Juan, Ru Qiang, Hu She-Jun, Guo Ling-Yun.Lithium intercalation properties of SnSb/C composite in carbonthermal reduction as the anode material for lithium ion battery. Acta Physica Sinica, 2014, 63(16): 168201.doi:10.7498/aps.63.168201
[15]	Zheng Shu-Wen, Fan Guang-Han, He Miao, Zhao Ling-Zhi.Theoretical study of the effect of W-doping on the conductivity of β-Ga2O3. Acta Physica Sinica, 2014, 63(5): 057102.doi:10.7498/aps.63.057102
[16]	Yao Hai-Feng, Xie Yue-E, Ouyang Tao, Chen Yuan-Ping.Thermal transport of graphene nanoribbons embedding linear defects. Acta Physica Sinica, 2013, 62(6): 068102.doi:10.7498/aps.62.068102
[17]	Zhang Yi-Jun, Yan Jin-Liang, Zhao Gang, Xie Wan-Feng.First-principles calculation and experimental study of Si-doped β-Ga2O3. Acta Physica Sinica, 2011, 60(3): 037103.doi:10.7498/aps.60.037103
[18]	Lin Qiong-Fei, Xia Hai-Ping, Wang Jin-Hao, Zhang Yue-Pin, Zhang Qin-Yuan.Effect of Ga2O3 on the spectroscopic properties of Tm3+-doped GeO2-Ga2O3-Li2O-BaO-La2O3 glasses. Acta Physica Sinica, 2008, 57(4): 2554-2561.doi:10.7498/aps.57.2554
[19]	Ma Hai-Lin, Su Qing, Lan Wei, Liu Xue-Qin.Influence of oxygen pressure on the structure and photoluminescence of β-Ga2O3 nano-material prepared by thermal evaporation. Acta Physica Sinica, 2008, 57(11): 7322-7326.doi:10.7498/aps.57.7322
[20]	Zhang Chun-Xiang, Lin Li-Bin, P. L. Leung, Tang Qiang, Mike Li, Luo Da-Ling.Thermoluminescence and optical stimulated luminescence of undoped α-Al2O3 single crystal. Acta Physica Sinica, 2004, 53(1): 291-295.doi:10.7498/aps.53.291

Catalog

Vol. 69, Issue 16 - 2020-08-20

Metrics

Abstract views:8062
PDF Downloads:208
Cited By:0

Search

Article