- 必威体育下载

姓名
邮箱
手机号码
标题
留言内容
验证码

Abstract

During the service of the spacecraft, it will be disturbed by the energetic particles and rays, and thus induce total ionizing dose (TID), displacement damage (DD) or single event effect (SEE) to generate inside the electronic system, which can seriously affect the service lifetime of the electronic components. The difference in structure and types of electronic components are less sensitive to the radiation effects, but bipolar transistor is strongly sensitive to ionizing radiation effect. As a basic component of bipolar circuits, the in-depth study of bipolar transistor ionization radiation effect is of significance for engineering. It has been shown that the an amount of hydrogen can inevitably introduced from an external source during the sealing process of the devices. The KOVAR alloy is widely used as a metal cap material of bipolar transistor in the process of encapsulation. The residual gas analysis (RGA) for sealed Kovar lid packages is shown to have 1%–2% of the hydrogen in the cavity. The source of the hydrogen is generally considered to be out-gassing from the gold plating on the KOVAR. So far, the researches have focused on the study of the ionization damage effect of bipolar transistors with different structures under ⁶⁰Co gamma ray irradiation. There is lack of systemic study on the comparison of transistors packaged with and without cap.In this paper, we study the influence of sealed KOVAR lid packaged on ionizing radiation damage of lateral PNP bipolar transistor (LPNP) by using ⁶⁰Co gamma ray as an irradiation source. The semiconductor parameter analyzer is used to measure the electrical parameters of LPNP transistor during irradiation. The irradiation defects in LPNP transistors packaged with and without cap are characterized by deep level transient spectroscopy (DLTS). Experimental results show that the LPNP transistors packaged with and without cap have similar electrical characteristics. The base current increases with the total dose increasing, while the collector current remains almost constant. The degradation of LPNP transistor packaged with cap is more serious. According to the excess base current varying with base-emitter voltage for the LPNP transistors packaged with and without cap, the degradation of bipolar transistor packaged with cap is more serious under the same irradiation conditions. According to the analysis of DLTS, comparing with bipolar transistor packaged without cap, the signal peak at about 300 K is shifted to the left for the bipolar transistor packaged with cap. These results indicate that the LPNP transistors packaged with cap can generate more interface states during irradiation, which is attributed to a large amount of hydrogen and water vapor out-gassing from the gold plating on the KOVAR, which is released under the thermal stress. In the sealed environment, hydrogen can only diffuse into the device cavity, and is combined with the metal material in the transistor to form metal hydride. Therefore the degradation of transistor is severe under the same irradiation condition.

Keywords:

Authors and contacts

Corresponding author:Li Xing-Ji,lxj0218@hit.edu.cn

Funds:Project supported by the National Natural Science Foundation of China (Grant No. 61404038)

FullText HTML: translate this paragraph

References

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]

Cited By

DownLoad: Full-Size Img PowerPoint

DownLoad: Full-Size Img PowerPoint

DownLoad: Full-Size Img PowerPoint

DownLoad: Full-Size Img PowerPoint

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]

[1]	Hu Chen-Yang, Liang Jia-Luo, Zheng Ri-Yi, Lu Jiu-Yang, Deng Wei-Yin, Huang Xue-Qin, Liu Zheng-You.One-dimensional synthetic waterborne phononic crystals. Acta Physica Sinica, 2024, 73(10): 104301.doi:10.7498/aps.73.20240298
[2]	Dai Mei-Qin, Zhang Qing-Yue, Zhao Qiu-Ling, Wang Mao-Rong, Wang Xia.Controllable characteristics of interface states in one-dimensional inverted symmetric photonic structures. Acta Physica Sinica, 2022, 71(20): 204205.doi:10.7498/aps.71.20220383
[3]	Gao Hui-Fen, Zhou Xiao-Fang, Huang Xue-Qin.Zak phase induced interface states in two-dimensional phononic crystals. Acta Physica Sinica, 2022, 71(4): 044301.doi:10.7498/aps.71.20211642
[4]	Li Shun, Song Yu, Zhou Hang, Dai Gang, Zhang Jian.Statistical characteristics of total ionizing dose effects of bipolar transistors. Acta Physica Sinica, 2021, 70(13): 136102.doi:10.7498/aps.70.20201835
[5]	.Zak phase induces interface states in two-dimensional phononic crystals. Acta Physica Sinica, 2021, (): .doi:10.7498/aps.70.20211642
[6]	Yang Jian-Qun, Dong Lei, Liu Chao-Ming, Li Xing-Ji, Xu Peng-Fei.Impact of nitride passivation layer on ionizing irradiation damage on LPNP bipolar transistors. Acta Physica Sinica, 2018, 67(16): 168501.doi:10.7498/aps.67.20172215
[7]	Jia Zi-Yuan, Yang Yu-Ting, Ji Li-Yu, Hang Zhi-Hong.Deterministic interface states in photonic crystal with graphene-allotrope-like complex unit cells. Acta Physica Sinica, 2017, 66(22): 227802.doi:10.7498/aps.66.227802
[8]	Wang Qing-Hai, Li Feng, Huang Xue-Qin, Lu Jiu-Yang, Liu Zheng-You.The topological phase transition and the tunable interface states in granular crystal. Acta Physica Sinica, 2017, 66(22): 224502.doi:10.7498/aps.66.224502
[9]	Zhou Hang, Zheng Qi-Wen, Cui Jiang-Wei, Yu Xue-Feng, Guo Qi, Ren Di-Yuan, Yu De-Zhao, Su Dan-Dan.Enhanced channel hot carrier effect of 0.13 m silicon-on-insulator N metal-oxide-semiconductor field-effect transistor induced by total ionizing dose effect. Acta Physica Sinica, 2016, 65(9): 096104.doi:10.7498/aps.65.096104
[10]	Zhao Qi-Feng, Zhuang Yi-Qi, Bao Jun-Lin, Hu Wei.Quantitative separation of radiation induced charges for NPN bipolar junction transistors based on 1/f noise model. Acta Physica Sinica, 2015, 64(13): 136104.doi:10.7498/aps.64.136104
[11]	Liu Yuan, Chen Hai-Bo, He Yu-Juan, Wang Xin, Yue Long, En Yun-Fei, Liu Mo-Han.Radiation effects on the low frequency noise in partially depleted silicon on insulator transistors. Acta Physica Sinica, 2015, 64(7): 078501.doi:10.7498/aps.64.078501
[12]	Li Duo-Fang, Cao Tian-Guang, Geng Jin-Peng, Zhan Yong.Damage-repair model for mutagenic effects of plant induced by ionizing radiation. Acta Physica Sinica, 2015, 64(24): 248701.doi:10.7498/aps.64.248701
[13]	Ma Zhen-Yang, Chai Chang-Chun, Ren Xing-Rong, Yang Yin-Tang, Qiao Li-Ping, Shi Chun-Lei.The damage effect and mechanism of the bipolar transistor induced by different types of high power microwaves. Acta Physica Sinica, 2013, 62(12): 128501.doi:10.7498/aps.62.128501
[14]	Ren Xing-Rong, Chai Chang-Chun, Ma Zhen-Yang, Yang Yin-Tang, Qiao Li-Ping, Shi Chun-Lei.The damage effect and mechanism of bipolar transistors induced by injection of electromagnetic pulse from the base. Acta Physica Sinica, 2013, 62(6): 068501.doi:10.7498/aps.62.068501
[15]	Li Xing-Ji, Lan Mu-Jie, Liu Chao-Ming, Yang Jian-Qun, Sun Zhong-Liang, Xiao Li-Yi, He Shi-Yu.The influence of bias conditions on ionizing radiation damage of NPN and PNP transistors. Acta Physica Sinica, 2013, 62(9): 098503.doi:10.7498/aps.62.098503
[16]	Ma Zhen-Yang, Chai Chang-Chun, Ren Xing-Rong, Yang Yin-Tang, Chen Bin.The damage effect and mechanism of the bipolar transistor caused by microwaves. Acta Physica Sinica, 2012, 61(7): 078501.doi:10.7498/aps.61.078501
[17]	Chai Chang-Chun, Xi Xiao-Wen, Ren Xing-Rong, Yang Yin-Tang, Ma Zhen-Yang.The damage effect and mechanism of the bipolar transistor induced by the intense electromagnetic pulse. Acta Physica Sinica, 2010, 59(11): 8118-8124.doi:10.7498/aps.59.8118
[18]	Yang Li-Xia, Du Lei, Bao Jun-Lin, Zhuang Yi-Qi, Chen Xiao-Dong, Li Qun-Wei, Zhang Ying, Zhao Zhi-Gang, He Liang.The effect of 60Co γ-ray irradiation on the 1/f noise of Schottky barrier diodes. Acta Physica Sinica, 2008, 57(9): 5869-5874.doi:10.7498/aps.57.5869
[19]	Yang Lin-An, Zhang Yi-Men, Yu Chun-Li, Zhang Yu-Ming.Trapping effect modeling for SiC power MESFETs. Acta Physica Sinica, 2003, 52(2): 302-306.doi:10.7498/aps.52.302
[20]	REN HONG-XIA, HAO YUE, XU DONG-GANG.STUDY ON HOT-CARRIER-EFFECT FOR GROOVED-GATE N-CHANNEL METAL-OXIDE-SEMICONDUCTOR FIELD-EFFECT-TRANSISTOR. Acta Physica Sinica, 2000, 49(7): 1241-1248.doi:10.7498/aps.49.1241

Catalog

Vol. 69, Issue 1 - 2020-01-05

Metrics

Abstract views:7293
PDF Downloads:69
Cited By:0

Search

Article