- 必威体育下载

姓名
邮箱
手机号码
标题
留言内容
验证码

摘要

采用H等离子体处理p-GaN盖帽层来制备p-GaN栅AlGaN/GaN高电子迁移率晶体管(HEMT). 在p-GaN层表面上先沉积2 nm的Al ₂O ₃薄膜, 以减少H等离子体注入p-GaN时对表面造成的损伤. 经研究表明沉积Al ₂O ₃阻挡层的器件栅极反向泄漏电流降低了一个数量级, 开关比提高了约3倍. 由于栅极泄露电流的减小, 关态击穿电压从410 V提高到780 V. 针对栅极反向泄漏减小的现象, 进行了变温 I _G- V _G测试, 验证了栅极反向泄漏电流的主导机制是二维变程跳跃(Two-dimensional variable range hopping, 2D-VRH)模型. 分析了减小栅极反向电流的原因是由于Al ₂O ₃阻挡层改变了HR-GaN的表面态, 使陷阱能级的活化能升高. 此外, 器件动态特性也表现出更稳定的趋势, 这是Al ₂O ₃薄膜阻挡过多的H等离子体的注入, 使AlGaN势垒和沟道陷阱态数量减少, 电流崩塌效应减弱.

关键词:

Abstract

High electron mobility transistors(HEMTs)show tremendous potentials for high mobility, high breakdown voltage, low conduction, low power consumption, and occupy an important piece of the microelectronics field. The high-resistivity-cap-layer high electron mobility transistor (HRCL-HEMT) is a novel device structure. Based on the hole compensation mechanism, the p-GaN is converted into high resistance semiconductor material by hydrogen plasma implantation. Thus, the surface of the p-GaN layer will have a serious bombardment damage under the hydrogen plasma implantation. In practical work, it is also very challenging in the accurate controlling of the hydrogen injection rate, injection depth and injection uniformity. To achieve the required depth of injection, the injected hydrogen plasma is often more than the required dose or multiple injections times. The energy of hydrogen plasma plays a huge influence on the surface of the p-GaN layer.The leakage current will be generated on the device surface, which deteriorates the electrical performance of the device. In this work, to protect the surface of p-GaN layer, a 2-nm Al ₂O ₃film is deposited on the surface of the p-GaN cap layer to reduce the implantation damage caused by hydrogen plasma treatment. The research shows that after the device deposited Al ₂O ₃film prior to the hydrogen plasma treatment, the gate reverse leakage current is reduced by an order of magnitude, the ratio of I _ONto I _OFFis increased by about 3 times. Meanwhile, the OFF-state breakdown voltage is increased from 410 V to 780 V. In addition, when the bias voltage is 400 V, the values of dynamic R _ONof devices A and B are 1.49 and 1.45 respectively, the device B shows a more stable dynamic performance. To analyze the gate leakage mechanism, a temperature-dependent current I _G- V _Gtesting is carried out, and it is found that the dominant mechanism of gate leakage current is two-dimensional variable range hopping (2D-VRH) at reverse gate voltage. The reason for reducing the gate reverse current is analyzed, and the Al ₂O ₃film increases the activation energy of trap level and changes the surface states of HR-GaN; furthermore, the Al ₂O ₃film blocks the injection of too much H plasma, thereby reducing the density of AlGaN barrier and channel trap states, and weakening the current collapse.

Keywords:

作者及机构信息

1.
2.
3.

通信作者:邢艳辉,xingyanhui@bjut.edu.cn; 张宝顺,bszhang2006@sinano.ac.cn;

基金项目:中国科学院青年创新促进会(批准号: 2020321)、国家自然科学基金(批准号: 61904192, 61731019, 61575008, 61775007)和北京市自然科学基金(批准号: 4202010, 4172011)资助的课题.

Authors and contacts

1.
2.
3.

Corresponding author:Xing Yan-Hui,xingyanhui@bjut.edu.cn; Zhang Bao-Shun,bszhang2006@sinano.ac.cn;

Funds:Project supported by the Youth Innovation Promotion Association of CAS (Grant No. 2020321), and the National Natural Science Foundation of China (Grant Nos. 61904192, 61731019, 61575008, 61775007); Beijing Natural Science Foundation (Grant No.4202010, 4172011).

文章全文: translate this paragraph

参考文献

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]

施引文献

下载: 全尺寸图片幻灯片

器件E_a/meV	栅极电压/V
器件E_a/meV	–10	–9	–8	–7	–6	–5	–4	–3	–2	–1
A	308	321	332	343	353	366	385	404	433	466
B	382	402	422	439	455	470	489	511	524	531

下载: 导出CSV

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]

[1]	梁琦, 王如志, 杨孟骐, 王长昊, 刘金伟.Al₂O₃衬底无催化剂生长GaN纳米线及其光学性能. 必威体育下载 , 2020, 69(8): 087801.doi:10.7498/aps.69.20191923
[2]	邓小庆, 邓联文, 何伊妮, 廖聪维, 黄生祥, 罗衡.InGaZnO薄膜晶体管泄漏电流模型. 必威体育下载 , 2019, 68(5): 057302.doi:10.7498/aps.68.20182088
[3]	李淑萍, 张志利, 付凯, 于国浩, 蔡勇, 张宝顺.基于原位等离子体氮化及低压化学气相沉积-Si3N4栅介质的高性能AlGaN/GaN MIS-HEMTs器件的研究. 必威体育下载 , 2017, 66(19): 197301.doi:10.7498/aps.66.197301
[4]	闫大为, 李丽莎, 焦晋平, 黄红娟, 任舰, 顾晓峰.原子层沉积Al2O3/n-GaN MOS结构的电容特性. 必威体育下载 , 2013, 62(19): 197203.doi:10.7498/aps.62.197203
[5]	郑玉龙, 甄聪棉, 马丽, 李秀玲, 潘成福, 侯登录.Si-Al2O3复合薄膜的室温铁磁性. 必威体育下载 , 2011, 60(11): 117502.doi:10.7498/aps.60.117502
[6]	廖国进, 骆红, 闫绍峰, 戴晓春, 陈明.基于透射光谱确定溅射Al2O3薄膜的光学（已撤稿）. 必威体育下载 , 2011, 60(3): 034201.doi:10.7498/aps.60.034201
[7]	王林, 胡伟达, 陈效双, 陆卫.AlGaN/GaN HEMT器件电流坍塌和膝点电压漂移机理的研究. 必威体育下载 , 2010, 59(8): 5730-5737.doi:10.7498/aps.59.5730
[8]	陈益峰, 陈熙萌, 娄凤君, 徐进章, 绍剑雄, 孙光智, 王俊, 席发元, 尹永智, 王兴安, 徐俊奎, 崔莹, 丁宝卫.Al2O3微孔膜对60 keV O+离子的“导向”效应. 必威体育下载 , 2010, 59(1): 222-226.doi:10.7498/aps.59.222
[9]	丁国建, 郭丽伟, 邢志刚, 陈耀, 徐培强, 贾海强, 周均铭, 陈弘.使用AlN/GaN超晶格势垒层生长高Al组分AlGaN/GaN HEMT结构. 必威体育下载 , 2010, 59(8): 5724-5729.doi:10.7498/aps.59.5724
[10]	刘林杰, 岳远征, 张进城, 马晓华, 董作典, 郝跃.Al2O3绝缘栅AlGaN/GaN MOS-HEMT器件温度特性研究. 必威体育下载 , 2009, 58(1): 536-540.doi:10.7498/aps.58.536
[11]	李盛涛, 成鹏飞, 李建英.Al2O3单晶三明治结构的高温热激发电流. 必威体育下载 , 2008, 57(12): 7783-7788.doi:10.7498/aps.57.7783
[12]	席光义, 任凡, 郝智彪, 汪莱, 李洪涛, 江洋, 赵维, 韩彦军, 罗毅.AlGaN表面坑状缺陷及GaN缓冲层位错缺陷对AlGaN/GaN HEMT电流崩塌效应的影响. 必威体育下载 , 2008, 57(11): 7238-7243.doi:10.7498/aps.57.7238
[13]	魏巍, 林若兵, 冯倩, 郝跃.场板结构AlGaN/GaN HEMT的电流崩塌机理. 必威体育下载 , 2008, 57(1): 467-471.doi:10.7498/aps.57.467
[14]	吕玲, 龚欣, 郝跃.感应耦合等离子体刻蚀p-GaN的表面特性. 必威体育下载 , 2008, 57(2): 1128-1132.doi:10.7498/aps.57.1128
[15]	冯倩, 郝跃, 岳远征.Al2O3绝缘层的AlGaN/GaN MOSHEMT器件研究. 必威体育下载 , 2008, 57(3): 1886-1890.doi:10.7498/aps.57.1886
[16]	郝跃, 韩新伟, 张进城, 张金凤.AlGaN/GaN HEMT器件直流扫描电流崩塌机理及其物理模型. 必威体育下载 , 2006, 55(7): 3622-3628.doi:10.7498/aps.55.3622
[17]	顾伟超, 沈德久, 王玉林, 陈光良, 冯文然, 张谷令, 刘赤子, 杨思泽.电解等离子体法制备Al2O3陶瓷层及其特性研究. 必威体育下载 , 2005, 54(7): 3263-3267.doi:10.7498/aps.54.3263
[18]	郭得峰, 耿伟刚, 兰伟, 黄春明, 王印月.Y掺杂Al2O3高k栅介质薄膜的制备及性能研究. 必威体育下载 , 2005, 54(12): 5901-5906.doi:10.7498/aps.54.5901
[19]	方志军, 夏义本, 王林军, 张伟丽, 马哲国, 张明龙.Al2O3陶瓷衬底碳离子预注入对金刚石薄膜应力的影响研究. 必威体育下载 , 2003, 52(4): 1028-1033.doi:10.7498/aps.52.1028
[20]	金通政, 韩世莹, 睦云霞.α-Al2O3单晶中Fe3+离子的电子顺磁共振. 必威体育下载 , 1988, 37(1): 147-151.doi:10.7498/aps.37.147

计量

文章访问数:4884
PDF下载量:179
被引次数:0

搜索

留言板