-
偏滤器靶板钨/铜瓦片在高热流作用下的热表现是未来托卡马克ITER最受关注的问题之一. 由于安装精度等因素, 钨/铜瓦片会出现排布位错从而产生凸出棱边, 凸出棱边处能流密度极大, 严重侵蚀靶板. 建立了二维对流传热的自洽模型, 包括热辐射、汽化和熔化效应, 同时, 耦合冷却水状态变化, 研究类ITER第一类边界局域模热流对出现排布位错的偏滤器靶板钨/铜瓦片的腐蚀程度, 比较直角、斜边瓦片的热性能. 为了研究瓦片缝隙、排布误差对等离子体行为和能流密度分布的影响, 利用二维边缘等离子体动理学程序计算不同排布误差下两种形状瓦片表面的能流密度分布, 并作为热传导模型的输入参数. 研究结果表明: 瓦片缝隙附近等离子体行为会受排布误差影响, 不同排布误差下的直角、斜边瓦片边缘处能流密度分布不同, 对两种形状瓦片的热表现影响极大, 排布误差越大, 两种形状瓦片的热腐蚀程度越大; 相对于直角瓦片, 斜边瓦片在边界局域模热流作用下的热腐蚀程度较小, 且有较好的对抗排布位错的能力.The thermal performance of the divertor W/Cu monoblock tiles under the ITER-like transient events has been one of the main concerns for ITER plasma facing components. Owing to the assembly tolerances during installation, the leading edge caused by misalignment between toroidal neighboring tiles will receive the extremely high cumulative heat flux and be damaged. In this work, we develop a two-dimensional heat conductivity model, including evaporation, radiation, melting process, and coupling cooling water condition, to investigate the thermal erosion of two shapes of tiles of W/Cu monoblock (unshaped and beveled tiles) with misalignment in a range from 0 to 0.3 mm, within the allowable maximum misalignment for ITER. To reflect the geometrical effects of castellated divertor tiles on the properties of its adjacent plasma, the energy flux density distribution arriving at the castellated divertor tile surface is evaluated first by using a two-dimension-in-space and three-dimension-in-velocity particle-in-cell plus Monte Carlo collisions code, and the obtained energy flux distribution is then used as input for the heat conduction model. The simulation results show that the maximum temperature of the unshaped tile with no misalignment is lower than that of the beveled tile under the steady-state inter-ELM heat flux, which increases more quickly than that of the beveled tile with misalignment increasing and will be larger than that of the beveled tile when misalignment is not less than 0.105 mm. Two shapes of the divertor tiles would melt and vaporize under typical heat flux density of a transient event of type-I edge localized modes (ELMs) for ITER, deposition energy of 1 MJ·m –2in a duration of 600 μs. The highest temperature, the maximum melting thickness, the maximum vaporization thickness of the unshaped tile with no misalignment are higher than those of the beveled tile except the melting volume ratio. The thermal erosion of the unshaped tile increases more remarkably than that of the beveled tile with misalignment increasing, and the melting volume ratio of the unshaped tile will exceed that of the beveled tile at a misalignment of 0.17 mm. In comparison with the unshaped tile, the beveled tile is more resistant to such a high heat flux of an ELM and misalignment.
[1] [2] [3] [4] [5] [6] [7] [8] [9] [10] [11] [12] [13] [14] [15] [16] [17] [18] [19] [20] [21] [22] [23] [24] [25] [26] [27] [28] [29] [30] [31] [32] [33] [34] [35] [36] [37] [38] [39] [40] -
[1] [2] [3] [4] [5] [6] [7] [8] [9] [10] [11] [12] [13] [14] [15] [16] [17] [18] [19] [20] [21] [22] [23] [24] [25] [26] [27] [28] [29] [30] [31] [32] [33] [34] [35] [36] [37] [38] [39] [40] -
[1] 秦梦飞, 王英敏, 张红玉, 孙继忠. 〈100〉 间隙型位错环在纯钨及含氦杂质钨(010)表面下运动行为的分子动力学模拟. 必威体育下载 , 2023, 72(24): 245204.doi:10.7498/aps.72.20230651[2] 徐驰, 万发荣.聚变材料钨辐照后退火形成的位错环特性及inside-outside衬度分析. 必威体育下载 , 2023, 72(5): 056801.doi:10.7498/aps.72.20222124 [3] 秦晨晨, 牟茂淋, 陈少永.负三角形变位型下剥离气球模的非线性演化特征. 必威体育下载 , 2023, 72(4): 045203.doi:10.7498/aps.72.20222138 [4] 黄艳, 孙继忠, 桑超峰, 胡万鹏, 王德真.边界局域模引起钨偏滤器靶板侵蚀和形貌变化的数值模拟研究. 必威体育下载 , 2017, 66(3): 035201.doi:10.7498/aps.66.035201 [5] 黄艳, 孙继忠, 桑超峰, 丁芳, 王德真.边界局域模对EAST钨偏滤器靶板腐蚀程度的数值模拟研究. 必威体育下载 , 2014, 63(3): 035204.doi:10.7498/aps.63.035204 [6] 陈丽群, 于涛, 彭小芳, 刘健.难熔元素钨在NiAl位错体系中的占位及对键合性质的影响. 必威体育下载 , 2013, 62(11): 117101.doi:10.7498/aps.62.117101 [7] 杨顺华, 李国旺, 黄军平.二相介质中的运动位错. 必威体育下载 , 1991, 40(5): 771-780.doi:10.7498/aps.40.771 [8] 高飞, 张宏图.位错规范场对于位错芯区的应用. 必威体育下载 , 1989, 38(7): 1127-1133.doi:10.7498/aps.38.1127 [9] 高飞, 张宏图.存在异性夹杂的位错塞积. 必威体育下载 , 1988, 37(8): 1315-1325.doi:10.7498/aps.37.1315 [10] 陈金长, 黄依森, 魏培才.KDP晶体中位错的研究. 必威体育下载 , 1985, 34(3): 377-380.doi:10.7498/aps.34.377 [11] 龙期威, 王屴.位错在裂纹顶端的象力. 必威体育下载 , 1984, 33(9): 1337-1340.doi:10.7498/aps.33.1337 [12] 郭常霖.α—SiC晶体中的位错. 必威体育下载 , 1982, 31(11): 1511-1525.doi:10.7498/aps.31.1511 [13] 郭可信, 林保军.镍铬合金中的位错运动与位错反应. 必威体育下载 , 1978, 27(6): 729-745.doi:10.7498/aps.27.729 [14] 刘振茂, 王贵华, 洪晶, 叶以正.硅中位错增殖的实验观察. 必威体育下载 , 1966, 22(9): 1077-1097.doi:10.7498/aps.22.1077 [15] 邢修三.空位位错环的形成. 必威体育下载 , 1966, 22(5): 541-546.doi:10.7498/aps.22.541 [16] 葛庭燧, 张志舜, 张进修.铝-0.1%镁合金中表现反常振幅效应的低频位错内耗峰. 必威体育下载 , 1966, 22(3): 270-280.doi:10.7498/aps.22.270 [17] 洪晶, 叶以正.硅中位错运动速度. 必威体育下载 , 1965, 21(12): 1968-1976.doi:10.7498/aps.21.1968 [18] 葛庭燧, 张进修.Al-0.5%Cu合金中表现反常振幅效应的低频位错内耗. 必威体育下载 , 1965, 21(10): 1711-1724.doi:10.7498/aps.21.1711 [19] 闵乃本, 吉光民, 冯端.钨单晶体中位错的侵蚀斑. 必威体育下载 , 1964, 20(11): 1182-1186.doi:10.7498/aps.20.1182 [20] 孙瑞蕃, М.П.沙斯柯里斯卡娅.晶体中滑移的位错机构研究. 必威体育下载 , 1960, 16(4): 229-240.doi:10.7498/aps.16.229
下载:
计量
- 文章访问数:1990
- PDF下载量:48
- 被引次数:0