- 必威体育下载

姓名
邮箱
手机号码
标题
留言内容
验证码

摘要

本征钝化层及p型发射层对硅异质结太阳电池的性能具有重要的影响. 本文在常规钝化层与晶硅衬底(c-Si)之间插入一层低功率、高氢稀释比沉积的超薄缓冲层, 以此来提高钝化效果, 并拓宽钝化层工艺窗口. 此外, 设计并制备了具有宽带隙、高电导特性的重掺杂纳米晶硅/轻掺杂p型双层复合发射极. 实验结果表明, 双层钝化层具有更加稳定与优异的钝化效果, 钝化样品的少子寿命达到4.197 ms, 隐含开路电压(implied- V _OC, iV _OC)达到726 mV. 同时双层复合发射层中, 轻掺杂的掺杂层可以减弱掺杂剂向本征钝化层的扩散, 保证良好的钝化效果, 而重掺杂的掺杂层不仅能够提供足够的内建电场, 而且可以改善掺杂层与氧化铟锡薄膜的接触特性, 进而提升电池的输出特性. 并且高氢稀释比的前掺杂层还可以对钝化层起到氢处理的作用, 减少钝化层表面的悬挂键, 从而增强化学钝化效果, 进而提高电池的开路电压. 最终, 基于商业化制绒的硅片, 获得了效率达到20.96%的硅异质结太阳电池, 其中开路电压为710 mV, 短路电流密度为39.88 mA/cm ², 填充因子为74.02%.

关键词:

Abstract

Silicon heterojunction (SHJ) solar cells have attracted much attention in the international photovoltaic market due to their high efficiencies and low costs. The quality of amorphous silicon/crystalline silicon (a-Si:H/c-Si) interfaces of SHJ solar cells has a key influence on the device performance. Therefore, the carrier recombination rate of a-Si:H/c-Si interface needs to be effectively controlled. In addition, as the important component of SHJ solar cells, the p-type emitter must meet the requirements for high conductivity, high light transmittance, and energy band matching with c-Si. The research contents and the relevant achievements of this paper include the following aspects. Firstly, in order to reduce the surface defects and realize the energy band alignment of a-Si:H/c-Si interface, the effect of passivation layer on passivation effect is studied. An ultra-thin buffer layer deposited by a low power and a high hydrogen dilution ratio is inserted between the conventional passivation layer and c-Si to improve the passivation effect and broaden the process window of passivation layer. The effects of the buffer layer thickness and hydrogen dilution ratio on passivation quality are further studied, and the best experimental conditions of buffer layer are obtained. The experimental results show that the sample with double-layered passivation layer is more stable than the conventional passivation layer. The minority carrier lifetime of the sample with single conventional passivation layer is 3.8 ms and the iV _OCis 712 mV, while the minority carrier lifetime of the sample with double-layered passivation layer is 4.197 ms and the iV _OCis 726 mV. Secondly, for the p-type emitters of silicon heterojunction solar cells, the effects of doping level on the photoelectric properties of p-type hydrogenated nanocrystalline silicon (nc-Si:H) thin films are studied. On this basis, the p ⁺⁺-nc-Si:H/p-nc-Si:H double-layer emitter with wide band gap and high conductivity is designed and fabricated. By analyzing the optical and electrical properties of different emitters, it is found that p-nc-Si:H has good electrical and optical properties. Owing to the high doping efficiency of nc-Si, a small amount of doping can obtain high conductivity. Lightly doped p-nc-Si:H provides a better contact with the passivation layer, while heavily doped p ⁺⁺-nc-Si:H can not only provide enough built-in electric field, but also improve the contact characteristics of p/ITO, thus enhancing the output characteristics of the cell. At the same time, the deposition of p-nc-Si:H layer with high hydrogen dilution ratio can also implement the hydrogen plasma treatment on the passivation layer, the reduction of the dangling bonds on the surface of the c-Si, the enhancement of the chemical passivation effect, and thus improving the open circuit voltage of the cell. Finally, a silicon heterojunction solar cell with an efficiency of 20.96% is obtained based on the commercial czochralski silicon wafer, with an open circuit voltage of 710 mV, a short circuit current density of 39.88 mA/cm ²and filling factor of 74.02%.

Keywords:

作者及机构信息

1.
2.
3.
4.

通信作者:侯国付,gfhou@nankai.edu.cn

基金项目:国家重点研发计划(批准号: 2018YFB1500402)和国家自然科学基金(批准号: 62074084)资助的课题

Authors and contacts

1.
2.
3.
4.

Corresponding author:Hou Guo-Fu,gfhou@nankai.edu.cn

Funds:Project supported by the National Key R&D Program of China (Grant No. 2018YFB1500402) and the National Natural Science Foundation of China (Grant No. 62074084)

文章全文: translate this paragraph

参考文献

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]
[30]
[31]
[32]
[33]

施引文献

下载: 全尺寸图片幻灯片

H₂∶SiH₄∶TMB	J_SC/mA·cm^–2	V_OC/V	FF/%	Eff/%
120∶4∶4	38.7	0.709	66.57	18.26
160∶4∶4	38.91	0.710	69.08	19.08
200∶4∶4	39.15	0.709	70.84	19.66
240∶4∶4	38.4	0.708	65.56	17.8

下载: 导出CSV

H₂∶SiH₄∶TMB	J_SC/mA·cm^–2	V_OC/V	FF/%	Eff/%
200∶4∶4	39.15	0.709	70.84	19.66
200∶4∶4.8	39.37	0.708	71.86	20.03
200∶4∶5.6	38.79	0.709	69.71	19.17
200∶4∶6.4	38.7	0.710	63.20	17.3

下载: 导出CSV

[1]
[2]
[3]
[4]
[5]
[6]
[7]
[8]
[9]
[10]
[11]
[12]
[13]
[14]
[15]
[16]
[17]
[18]
[19]
[20]
[21]
[22]
[23]
[24]
[25]
[26]
[27]
[28]
[29]
[30]
[31]
[32]
[33]

[1]	肖忆瑶, 何佳豪, 陈南锟, 王超, 宋宁宁.基于负载Fe₃O₄纳米微球的大尺寸单层二维Ti₃C₂T_x微波吸收性能. 必威体育下载 , 2023, 72(21): 217501.doi:10.7498/aps.72.20231200
[2]	赵建宁, 魏东, 吕国正, 王子成, 刘冬欢.一维异质结构的瞬态热整流效应. 必威体育下载 , 2023, 72(4): 044401.doi:10.7498/aps.72.20222085
[3]	王琛, 温盼, 彭聪, 徐萌, 陈龙龙, 李喜峰, 张建华.钝化层对背沟道刻蚀型IGZO薄膜晶体管的影响. 必威体育下载 , 2023, 72(8): 087302.doi:10.7498/aps.72.20222272
[4]	曹宇, 刘超颖, 赵耀, 那艳玲, 江崇旭, 王长刚, 周静, 于皓.双电子传输层结构硫硒化锑太阳电池的界面特性优化. 必威体育下载 , 2022, 71(3): 038802.doi:10.7498/aps.71.20211525
[5]	王其, 延玲玲, 陈兵兵, 李仁杰, 王三龙, 王鹏阳, 黄茜, 许盛之, 侯国付, 陈新亮, 李跃龙, 丁毅, 张德坤, 王广才, 赵颖, 张晓丹.钙钛矿/硅异质结叠层太阳电池: 光学模拟的研究进展. 必威体育下载 , 2021, 70(5): 057802.doi:10.7498/aps.70.20201585
[6]	陈俊帆, 任慧志, 侯福华, 周忠信, 任千尚, 张德坤, 魏长春, 张晓丹, 侯国付, 赵颖.钙钛矿/硅叠层太阳电池中平面a-Si:H/c-Si异质结底电池的钝化优化及性能提高. 必威体育下载 , 2019, 68(2): 028101.doi:10.7498/aps.68.20181759
[7]	檀满林, 周丹丹, 符冬菊, 张维丽, 马清, 李冬霜, 陈建军, 张化宇, 王根平.基于BiFeO3/ITO复合膜表面钝化的黑硅太阳电池性能研究. 必威体育下载 , 2017, 66(16): 167701.doi:10.7498/aps.66.167701
[8]	张晓宇, 张丽平, 马忠权, 刘正新.硅锗量子阱结构在硅异质结太阳电池中应用的数值模拟. 必威体育下载 , 2016, 65(13): 138801.doi:10.7498/aps.65.138801
[9]	许中华, 陈卫兵, 叶玮琼, 杨伟丰.聚合物和小分子叠层结构有机太阳电池研究. 必威体育下载 , 2014, 63(21): 218801.doi:10.7498/aps.63.218801
[10]	於黄忠.有机共混结构叠层太阳电池的研究进展. 必威体育下载 , 2013, 62(2): 027201.doi:10.7498/aps.62.027201
[11]	薛源, 郜超军, 谷锦华, 冯亚阳, 杨仕娥, 卢景霄, 黄强, 冯志强.薄膜硅/晶体硅异质结电池中本征硅薄膜钝化层的性质及光发射谱研究. 必威体育下载 , 2013, 62(19): 197301.doi:10.7498/aps.62.197301
[12]	曹宇, 张建军, 李天微, 黄振华, 马峻, 倪牮, 耿新华, 赵颖.微晶硅锗太阳电池本征层纵向结构的优化. 必威体育下载 , 2013, 62(3): 036102.doi:10.7498/aps.62.036102
[13]	郑雪, 余学功, 杨德仁.-Si：H/SiNx叠层薄膜对晶体硅太阳电池的钝化. 必威体育下载 , 2013, 62(19): 198801.doi:10.7498/aps.62.198801
[14]	侯国付, 卢鹏, 韩晓艳, 李贵君, 魏长春, 耿新华, 赵颖.提高非晶硅/微晶硅叠层太阳电池光稳定性的研究. 必威体育下载 , 2012, 61(13): 138401.doi:10.7498/aps.61.138401
[15]	张晓丹, 郑新霞, 王光红, 许盛之, 岳强, 林泉, 魏长春, 孙建, 张德坤, 熊绍珍, 耿新华, 赵颖.单室沉积高效非晶硅/微晶硅叠层太阳电池的研究. 必威体育下载 , 2010, 59(11): 8231-8236.doi:10.7498/aps.59.8231
[16]	孙明昭, 张淳民, 宋晓平.新型八边形谐振环金属线复合周期结构左手材料奇异性质研究. 必威体育下载 , 2010, 59(8): 5444-5449.doi:10.7498/aps.59.5444
[17]	周骏, 邸明东, 孙铁囤, 孙永堂, 汪昊.界面缺陷态密度与衬底电阻率取值对硅异质结光伏电池性能的影响. 必威体育下载 , 2010, 59(12): 8870-8876.doi:10.7498/aps.59.8870
[18]	孟利军, 肖化平, 唐超, 张凯旺, 钟建新.碳纳米管-硅纳米线复合结构的形成和热稳定性. 必威体育下载 , 2009, 58(11): 7781-7786.doi:10.7498/aps.58.7781
[19]	袁育杰, 侯国付, 薛俊明, 韩晓艳, 刘云周, 杨兴云, 刘丽杰, 董培, 赵颖, 耿新华.微晶硅n-i-p太阳电池中n型掺杂层对本征层结构特性的影响. 必威体育下载 , 2008, 57(6): 3892-3897.doi:10.7498/aps.57.3892
[20]	赵雷, 周春兰, 李海玲, 刁宏伟, 王文静.a-Si(n)/c-Si(p)异质结太阳电池薄膜硅背场的模拟优化. 必威体育下载 , 2008, 57(5): 3212-3218.doi:10.7498/aps.57.3212

计量

文章访问数:6990
PDF下载量:260
被引次数:0

搜索

留言板